关键字
协会热线:029-84276641
            首页微电机期刊
 
  综述
  伺服与控制
  设计与研究
  专题讲座
  检测技术
  工艺技术
  经验交流
  实用技术
  读者园地
  技术交流
  使用与维护
  标准评述
  工艺与装备
  驱动与控制
  应用研究
  测试研究
  精品连载
 
标题:不同PWM调制方式对无刷直流电机调速的影响
作者:荣军,李一鸣,万军华,等待
2015年第10期 访问次数:273次

摘要:首先阐述了五种PWM调制方式的调速原理,并且从功率器件能耗的角度出发,给出了PWM调速的选择原则,最终排除了HPWMLPWM调制方式。然后采用反电动势无位置传感器来获取BLDCM转子位置的方法在PSPICE中建立四种不同PWM调速仿真模型,最后给出了不同PWM调制模式下的控制信号、电枢电压和电流仿真波形。仿真结果表明:在同等输入300V电源电压的情况下,在HPWMLON调制方式下,除了在续流段电枢电压尖峰达到400 V,电枢电压稳定保持为300 V,而且谐波含量少。而其他三种PWM调制方式电枢电压尖峰最小为420 V,最大达到470 V,而且谐波含量丰富,因此采用HPWMLON调制方式,相比于其他三种PWM调制方式,更能够保证电机安全平稳的运行。
关键词:无刷直流电机;调速;PWM调制模式;电枢电压;仿真
Abstract: The paper studied the effects of speeding on different PWM modulation for brushless DC motor(BLDCM), and firstly elaborated the speeding principle of five PWM modulation methods (ONPWM, PWMON, HPWMLON, HONLPWM and HPWMLPWM). The selection principle of PWM speeding was given from the angle of power device energy consumption, and the HPWMLPWM modulation was finally excluded. Then the paper built the simulation models of four different PWM speeding by adopting the method of back EMF and without position sensor to obtain the rotor position in PSPICE, and at last wave the simulation waveforms of control signals, armature voltages and currents for different modes of PWM. The simulation results show that the armature voltage maintains the stability of 300 V and the harmonic content is little, and except the freewheeling segment armature voltage spikes up to 400 V under the same input power supply voltage 300 V case. While the armature voltage spikes for the minimum of 420 V, and the maximum reaches 470 V, and also the harmonic contents are rich for the other three PWM modulation methods. Therefore, HPWMLON modulation can be more safe and stable operation for motor compared with the other three PWM modulation methods.
Key words: BLDCM; speeding; PWM modulation pattern; armature voltage; simulation

 

 
 
 
    广告服务 |   商务合作 |   使用帮助 |   网站地图 |     主办:中国电器工业协会微电机分会      挂靠:西安微电机研究所有限公司      地址:西安市高新区上林苑四路36号(710117)
   copyright © www.china-micromotor.com.cn all rights reserved.     版权所有:微电机网     陕ICP备05005551号-2
 

西安微电机研究所有限公司公众平台
二维码

《微电机》杂志公众平台二维码